摘要
通过分子克隆手段获得大肠杆菌来源的羧酸酯酶BioH，采用定向进化的方法提高该酶的水解活性以提升其应用价值．通过PCR扩增，从大肠杆菌K12菌株中克隆得到羧酸酯酶BioH基因，目的基因长度为771bp，含256个氨基酸；将其连接到pET30a（＋）质粒上并转入BL21（DE3）宿主细胞中，经诱导表达得到所需的目的蛋白，该蛋白分子质量约为28．2ku．野生型的BioH水解对硝基苯丁酸酯（P—NPB）的活性为18U／mg，且该酶具有良好的热稳定性．以PNPB为底物进行高通量筛选，其水解底物为对硝基苯酚（PNP），在405nm处有最大吸收峰．挑选出水解活性提高的突变体，并通过2轮定向进化过程，成功筛选到7个水解活性提高的优良突变体，它们的活性分别提高了20％～100％．结构分析表明，突变体的突变位点均分布在远离活性中心的位置．
Carboxylesterase BioH of Escherichia coli is an important enzyme in the biotin synthesis. It contains a typical catalytic triad of Ser-His-Asp and displays significant carboxylesterase activities. The enzyme shows a broad substrate specificity with a preference for short acyl chain substrates. This property makes it a biocatalyst with a good application prospect. However, research on the use of this enzyme has been quite few to date. It shows great significance to get the protein and optimize its functions. In this study, BioH gene from E. coli K12 was cloned into pET30a（＋） using double digestion method by BamHI and HindllI and was overexpressed in E. coli BL21 （DE3） induced by isopropyl-13-D-thiogalactoside （IPTG）. BioH protein content was calculated by image processing software Quantity One. Its hydrolysis activity was determined by the rate of hydrolyzing p-nitrophenyl butyrate （p NPB）. And its thermostability was detected after the enzyme was incubated at 60 ℃ for 40 min. In order to improve its hydrolysis activity, a directed evolution method was carried out. p-NPB was used as the screening substrate. The product, p-nitrophenol, showed the biggest absorption value at 405 nm. The mutant library was built by error-prone PCR method with adjusted Mn^2＋ concentration. The complete length of the BioH gene was 771 bp and the molecular mass of the protein with 256 amino acids was about 28.2 ku. The targeted enzyme accounted for one quarter of the total expressed proteins. The enzyme＇s hydrolysis activity was shown as 18 U/mg and it retained 70Y00 of its hydrolysis activity after incubated at 60 ℃ for 40 min. The thermostability of the enzyme was the foundation in the enzyme application. The optimized concentration of Mn^2＋ in error-prone PCR was chosen as 0.1 mmol/L determined by agarose dectrophoresis of the brightness of PCR product band. And mutant library with a mortality rate of 20% to 40% was appropriate for selection. Sequence detection showed that the mutation rate was kept as 2
出处
《浙江大学学报（农业与生命科学版）》
CAS
CSCD
北大核心
2013年第6期607-612,共6页
Journal of Zhejiang University:Agriculture and Life Sciences
基金
国家自然科学基金资助项目(21176215
21176102)
关键词
羧酸酯酶BioH
克隆
表达
定向进化
水解活性
carboxylesterase BioH
cloning
expression
directed evolution
hydrolysis activity
