摘要
从商陆茎中提取色素用于羊毛织物的染色,并探讨其染色性能。研究不同色素用量、pH值、温度对羊毛织物染色性能的影响,探讨了商陆色素在羊毛纤维上的吸附机制以及染色织物的牢度。研究结果表明,羊毛织物的K/S值随着商陆色素用量的增加而提高,当色素用量大于6.0%,织物的K/S值基本不变。羊毛织物的K/S值随pH值的升高而降低,当pH值小于3.5时,羊毛织物的K/S值较大,染色深度较深;当pH值大于4.5时,色素的上染率很低。染色温度低于60℃时,染色织物呈玫瑰红色,染色温度高于60℃时,染色织物偏黄色。低温染色时,织物的水洗牢度较低;高温染色时,牢度有所提高。
Natural pigment extracted from Phytolacca was applied to wool fabric,and the dyeing property was investigated.The effect of dye bath pH valne,dyeing temperature and the amount of pigment on the dyed fabrics were analyzed.The adsorption mechanism of Phytolacca pigment on wool fabric and fastness of dyed fabrics were also investigated.The results indicated that K/S value of the dyed wool fabric increased with the increasing amount of Phytolacca pigment.When the amount of pigment was more than 6.0%,K/S values almost remained the same.The K/S values decreased with the increasing of dye bath pH values.When pH was smaller than 3.5,the colour strength values were greater;when pH value was higher than 4.5,the rate of pigment uptake was very low.It was found that while dyeing temperature was below 60 ℃,the color of dyed fabric appeared rose red,and the dyed fabric became yellowish when dyeing temperature exceeded 60 ℃.The washing fastness of fabric dyed in low temperature was lower,and was improved at high dyeing temperature.
出处
《纺织学报》
EI
CAS
CSCD
北大核心
2012年第4期74-77,共4页
Journal of Textile Research
基金
国家自然科学基金项目(20674031)
江苏省企业博士创新项目(BK2009672)
关键词
商陆
染色性能
天然色素
羊毛织物
色牢度
Phytolacca pigment
dyeing property
natural dye
wool fabric
dyeing fastness
