Non-porous polyether sulfone hollow fibers(with a 5 μm poly(dimethylsiloxane)coating)were used as structured packing in the distillation of ethanol-water solutions.In this novel membrane contactor,liquid flowed throu...Non-porous polyether sulfone hollow fibers(with a 5 μm poly(dimethylsiloxane)coating)were used as structured packing in the distillation of ethanol-water solutions.In this novel membrane contactor,liquid flowed through the lumens of the fibers,and vapor flowed countercurrently outside the fibers.The results showed that the new membrane contactor gave better,more productive separations than traditional packing in distillation.The minimal HETP of hollow fibers could reach as low as 5.8 cm,and the contactor worked well above the limit where flooding normally occurs in conventional cases.The overall mass-transfer coefficient and individual mass-transfer coefficients based on the gas side and liquid side were calculated respectively.The theoretical analysis indicated that the resistance in the liquid was responsible for more than half of the total resistance.展开更多
Ethanol perm-selective PDMS/PVDF composite membranes were prepared by curing polydimethylsiloxane (PDMS) with various cross-linking reagents,such as tetraethoxylsilane(TEOS),γ-aminopropyltriethoxylsilane(APTEOS), phe...Ethanol perm-selective PDMS/PVDF composite membranes were prepared by curing polydimethylsiloxane (PDMS) with various cross-linking reagents,such as tetraethoxylsilane(TEOS),γ-aminopropyltriethoxylsilane(APTEOS), phenyltrimethoxylsilane(PTMOS) and octyltrimethoxylsilane(OTMOS) as well.The cross-linking density and surface properties of the PDMS active layer were adjusted by varying cross-linking reagents.The pervaporation performance of PDMS membranes cured with different cross-linking reagents was investig...展开更多
Tetramethylpyrazine(TTMP),an important aroma compound,was produced by Bacillus amyloliquefaciens XJB-104 with distillers’grains as raw material.The yield of TTMP under optimized fermentation procedure was 3176.52 mg/...Tetramethylpyrazine(TTMP),an important aroma compound,was produced by Bacillus amyloliquefaciens XJB-104 with distillers’grains as raw material.The yield of TTMP under optimized fermentation procedure was 3176.52 mg/L.TTMP in the fermentation broth was purified and the purity(>99%)was measured by gas chromatography-mass spectrometry.Furthermore,the hepatoprotective activity of TTMP in ethanol-water system was evaluated by biochemical indicators of liver injury,parameters of antioxidant defense system and inflammatory response,and liver histopathological assessment in mice.Ethanol treatment increased serum levels of alanine aminotransferase,aspartate aminotransferase,alkaline phos-phatase and lactate dehydrogenase,suggesting liver damage.Both high and low dose of TTMP significantly decreased levels of these indicators.Furthermore,the reduction in the activities or concentrations of superoxide dismutase,catalase,reduced glutathione and malondialdehyde in liver tissue caused by ethanol was significantly alleviated by TTMP.Increased inflammatory cytokines including transcription factor,tumor necrosis factor,interleukin-1beta,interleukin,macrophage chemoattractant protein,inducible nitric oxide synthase and cyclooxygenase were also suppressed by TTMP treatment.It is concluded that TTMP in ethanol-water system has potential liver-protective activity,especially when ethanol is consumed at low doses for short periods of time.展开更多
Five Co-B amorphous alloy catalysts were prepared by chemical reduction in different media, including pure water and pure ethanol as well as the mixture of ethanol and water with variable ethanol content, Their cataly...Five Co-B amorphous alloy catalysts were prepared by chemical reduction in different media, including pure water and pure ethanol as well as the mixture of ethanol and water with variable ethanol content, Their catalytic properties were evaluated using liquid phase furfural hydrogenation to furfuryl alcohol as the probe reaction. It was found that the reaction media had no significant influence on either the amorphous structure of the Co-B catalyst or the electronic interaction between metallic Co and alloying B. This could successfully account for the fact that all the as-prepared Co-B catalysts exhibited almost the same selectivity to furfuryl alcohol and the same activity per surface area （ Rs ）, which could be considered as the intrinsic activity, since the nature of active sites remained unchanged. However, the activity per gram of Co （ R^mH ） of the as-prepared Co-B catalysts increased rapidly when the ethanol content in the water-ethanol mixture used as the reaction medium for catalyst preparation increased. This could be attributed to the rapid increase in the surface area possibly owing to the presence of more oxidized boron species which could serve as a support for dispersing the Co-B amorphous alloy particles.展开更多
Using SrC12-6H2O and Na2CO3 as the main raw materials and adding different complexons as modifiers with simple co-precipitation method, SrCO3 crystals with distinct morphologies like spherical, bundle-like, overlappin...Using SrC12-6H2O and Na2CO3 as the main raw materials and adding different complexons as modifiers with simple co-precipitation method, SrCO3 crystals with distinct morphologies like spherical, bundle-like, overlapping plate-like, hexagonal star-like, dumbbell-like, etc. can be synthesized in the ethanol-water mixtures. The samples were characterized by X-ray diffraction （XRD）, scanning electron microscopy （SEM） and Fourier transform infrared spectrograph （FT-IR）. The interrelated effect mechanism is presented in the end. Results show that the modifier carboxyl groups play a significant role in controlling the SrCO3 crystal morphologies, which can alter the crystal growth unit （Sr^2＋） supply mode and induce the crystal formation with the morphologies matching their spatial configurations.展开更多
文摘Non-porous polyether sulfone hollow fibers(with a 5 μm poly(dimethylsiloxane)coating)were used as structured packing in the distillation of ethanol-water solutions.In this novel membrane contactor,liquid flowed through the lumens of the fibers,and vapor flowed countercurrently outside the fibers.The results showed that the new membrane contactor gave better,more productive separations than traditional packing in distillation.The minimal HETP of hollow fibers could reach as low as 5.8 cm,and the contactor worked well above the limit where flooding normally occurs in conventional cases.The overall mass-transfer coefficient and individual mass-transfer coefficients based on the gas side and liquid side were calculated respectively.The theoretical analysis indicated that the resistance in the liquid was responsible for more than half of the total resistance.
基金supported by the Major State Basic Research Program of China(No.2009CB623404)National NaturalScience Foundation of China(Nos.20736003,20676067)+2 种基金National High Technology Research and Development Programof China(No.2007AA06Z317)Foundation of Ministry of Education of China(No.20070003130)Foundation of theState Key Laboratory of Chemical Engineering(SKL-ChE-08A01).
文摘Ethanol perm-selective PDMS/PVDF composite membranes were prepared by curing polydimethylsiloxane (PDMS) with various cross-linking reagents,such as tetraethoxylsilane(TEOS),γ-aminopropyltriethoxylsilane(APTEOS), phenyltrimethoxylsilane(PTMOS) and octyltrimethoxylsilane(OTMOS) as well.The cross-linking density and surface properties of the PDMS active layer were adjusted by varying cross-linking reagents.The pervaporation performance of PDMS membranes cured with different cross-linking reagents was investig...
基金This work was supported by the Xuanjiu Group Co.(W2016JSKF0081).
文摘Tetramethylpyrazine(TTMP),an important aroma compound,was produced by Bacillus amyloliquefaciens XJB-104 with distillers’grains as raw material.The yield of TTMP under optimized fermentation procedure was 3176.52 mg/L.TTMP in the fermentation broth was purified and the purity(>99%)was measured by gas chromatography-mass spectrometry.Furthermore,the hepatoprotective activity of TTMP in ethanol-water system was evaluated by biochemical indicators of liver injury,parameters of antioxidant defense system and inflammatory response,and liver histopathological assessment in mice.Ethanol treatment increased serum levels of alanine aminotransferase,aspartate aminotransferase,alkaline phos-phatase and lactate dehydrogenase,suggesting liver damage.Both high and low dose of TTMP significantly decreased levels of these indicators.Furthermore,the reduction in the activities or concentrations of superoxide dismutase,catalase,reduced glutathione and malondialdehyde in liver tissue caused by ethanol was significantly alleviated by TTMP.Increased inflammatory cytokines including transcription factor,tumor necrosis factor,interleukin-1beta,interleukin,macrophage chemoattractant protein,inducible nitric oxide synthase and cyclooxygenase were also suppressed by TTMP treatment.It is concluded that TTMP in ethanol-water system has potential liver-protective activity,especially when ethanol is consumed at low doses for short periods of time.
文摘Five Co-B amorphous alloy catalysts were prepared by chemical reduction in different media, including pure water and pure ethanol as well as the mixture of ethanol and water with variable ethanol content, Their catalytic properties were evaluated using liquid phase furfural hydrogenation to furfuryl alcohol as the probe reaction. It was found that the reaction media had no significant influence on either the amorphous structure of the Co-B catalyst or the electronic interaction between metallic Co and alloying B. This could successfully account for the fact that all the as-prepared Co-B catalysts exhibited almost the same selectivity to furfuryl alcohol and the same activity per surface area （ Rs ）, which could be considered as the intrinsic activity, since the nature of active sites remained unchanged. However, the activity per gram of Co （ R^mH ） of the as-prepared Co-B catalysts increased rapidly when the ethanol content in the water-ethanol mixture used as the reaction medium for catalyst preparation increased. This could be attributed to the rapid increase in the surface area possibly owing to the presence of more oxidized boron species which could serve as a support for dispersing the Co-B amorphous alloy particles.
基金the Key Scientific and Technological Project of Sichuan Province(No.03GG021-002)
文摘Using SrC12-6H2O and Na2CO3 as the main raw materials and adding different complexons as modifiers with simple co-precipitation method, SrCO3 crystals with distinct morphologies like spherical, bundle-like, overlapping plate-like, hexagonal star-like, dumbbell-like, etc. can be synthesized in the ethanol-water mixtures. The samples were characterized by X-ray diffraction （XRD）, scanning electron microscopy （SEM） and Fourier transform infrared spectrograph （FT-IR）. The interrelated effect mechanism is presented in the end. Results show that the modifier carboxyl groups play a significant role in controlling the SrCO3 crystal morphologies, which can alter the crystal growth unit （Sr^2＋） supply mode and induce the crystal formation with the morphologies matching their spatial configurations.
