雾滴参数是衡量喷雾效果的重要指标。为研究管道喷雾设施中喷雾压力与喷头孔径的改变对果园用空心圆锥雾喷头雾滴参数的影响,通过喷雾性能综合试验平台和激光粒度仪,测量3种孔径的空心圆锥雾喷头在8种压力下的雾滴颗粒群的散射谱,获得...雾滴参数是衡量喷雾效果的重要指标。为研究管道喷雾设施中喷雾压力与喷头孔径的改变对果园用空心圆锥雾喷头雾滴参数的影响,通过喷雾性能综合试验平台和激光粒度仪,测量3种孔径的空心圆锥雾喷头在8种压力下的雾滴颗粒群的散射谱,获得了雾滴参数随压力和孔径的变化规律,给出了各工况下的雾滴谱曲线,分析了雾滴粒径的大小、分布和均匀性,建立了基于压力和孔径的雾滴参数模型。结果表明:压力越大,孔径越小,雾滴越细小越均匀;数据拟合误差均小于0.012;雾滴均较细小且较均匀,主要以气溶胶的形式存在;主要是粒径小于40μm的雾滴(79.659%~93.374%);雾滴谱峰值均在30μm附近出现;压力大于0.80 MPa后喷雾效果更好,其中体积中值粒径(volume median diameter,VMD)为30.610~31.632μm,雾滴很细小,扩散比(diffusion ratio,DR)为0.901~0.916,雾滴很均匀,VMD和DR均随压力呈二次多项式变化规律(R^2均大于0.968),VMD和DR与孔径和压力均有良好的二元线性关系(R^2分别为0.928和0.937)。研究结果验证了研发管道恒压喷雾装置的重要性,为喷头选型,管道恒压喷雾装置的优化、喷雾压力的设定和喷雾效果的优化提供了参考。展开更多
观测和分档方案的数值模拟都证明气溶胶的谱分布特征对云滴谱的演变有直接影响继而作用于降水的发展。目前广泛使用的总体双参数云滴谱方案因为表征云滴谱的预报量不足,在凝结过程中云滴谱呈不正常的拓宽现象。因此在参数化方案中,气溶...观测和分档方案的数值模拟都证明气溶胶的谱分布特征对云滴谱的演变有直接影响继而作用于降水的发展。目前广泛使用的总体双参数云滴谱方案因为表征云滴谱的预报量不足,在凝结过程中云滴谱呈不正常的拓宽现象。因此在参数化方案中,气溶胶谱对云滴谱的影响未有明确结论。中科学院大气物理研究所(IAP)云降水物理与强风暴重点实验室(LACS)新研发的三参数方案(IAP-LACS)通过增加的预报量克服了云滴谱的拓宽问题,提高了云滴谱模拟的准确性。为了研究在参数化方案中气溶胶谱分布特征对云滴谱的影响,本文采用新方案进行WRF(Weather Research and Forecasting mode)大涡理想性试验,验证了新方案中气溶胶对数正态谱函数中数浓度、几何半径和标准差3个参量对云滴谱演变的影响。针对3个参量的敏感性试验表明新的气溶胶活化方案和三参数云滴凝结增长方案能够描述气溶胶谱对云滴谱演变的影响规律:气溶胶数浓度对云滴谱影响最显著,数浓度越高活化生成的云滴数量越多,云滴半径越小,云滴谱趋向窄谱,气溶胶数浓度低时,云滴数量少、半径大。较大的几何半径使气溶胶谱向大粒径移动,导致大云滴生成,标准差对云滴谱的影响最不显著。展开更多
To discuss the effects of pesticide viscosity on the atomisation characteristics of an agricultural nozzle, glycerite with different mass fractions was prepared to replace the pesticide. First, the atomisation region ...To discuss the effects of pesticide viscosity on the atomisation characteristics of an agricultural nozzle, glycerite with different mass fractions was prepared to replace the pesticide. First, the atomisation region of the nozzle was meshed and sized. Second, the speed and kinetic energy of the droplets at different positions in the atomisation region were measured by Phase Doppler Anemometry. The results demonstrated that the Sauter mean diameter, volume mean diameter and arithmetic mean diameter of droplets first decreased and then increased gradually in the axial direction of the atomisation region. Surface waves of a certain pattern were formed on the liquid surface, which was ejected by the disturbance of external air resistance. As the distance increased, the amplitude increased and the wave crest was broken into small droplets. These droplets then collided and agglomerated into large droplets under the effect of gravity. Droplets had an approximately symmetric distribution on the radial direction of the atomisation region, and the droplets were small in the middle and large at the two ends. The droplet size was positively related to the radial distance. Compared with the droplet speed at the two ends, the droplet speed at the axis was higher and the droplet size was smaller. Moreover, the kinetic energy of the droplets along the axial direction decreased sharply and then increased slowly. Droplets with high viscosity at the near end of the nozzle had small kinetic energy, and the effects of liquid viscosity on the atomisation characteristics of a nozzle could not be neglected. The droplet kinetic energy slightly increased at the far end.展开更多
文摘雾滴参数是衡量喷雾效果的重要指标。为研究管道喷雾设施中喷雾压力与喷头孔径的改变对果园用空心圆锥雾喷头雾滴参数的影响,通过喷雾性能综合试验平台和激光粒度仪,测量3种孔径的空心圆锥雾喷头在8种压力下的雾滴颗粒群的散射谱,获得了雾滴参数随压力和孔径的变化规律,给出了各工况下的雾滴谱曲线,分析了雾滴粒径的大小、分布和均匀性,建立了基于压力和孔径的雾滴参数模型。结果表明:压力越大,孔径越小,雾滴越细小越均匀;数据拟合误差均小于0.012;雾滴均较细小且较均匀,主要以气溶胶的形式存在;主要是粒径小于40μm的雾滴(79.659%~93.374%);雾滴谱峰值均在30μm附近出现;压力大于0.80 MPa后喷雾效果更好,其中体积中值粒径(volume median diameter,VMD)为30.610~31.632μm,雾滴很细小,扩散比(diffusion ratio,DR)为0.901~0.916,雾滴很均匀,VMD和DR均随压力呈二次多项式变化规律(R^2均大于0.968),VMD和DR与孔径和压力均有良好的二元线性关系(R^2分别为0.928和0.937)。研究结果验证了研发管道恒压喷雾装置的重要性,为喷头选型,管道恒压喷雾装置的优化、喷雾压力的设定和喷雾效果的优化提供了参考。
文摘观测和分档方案的数值模拟都证明气溶胶的谱分布特征对云滴谱的演变有直接影响继而作用于降水的发展。目前广泛使用的总体双参数云滴谱方案因为表征云滴谱的预报量不足,在凝结过程中云滴谱呈不正常的拓宽现象。因此在参数化方案中,气溶胶谱对云滴谱的影响未有明确结论。中科学院大气物理研究所(IAP)云降水物理与强风暴重点实验室(LACS)新研发的三参数方案(IAP-LACS)通过增加的预报量克服了云滴谱的拓宽问题,提高了云滴谱模拟的准确性。为了研究在参数化方案中气溶胶谱分布特征对云滴谱的影响,本文采用新方案进行WRF(Weather Research and Forecasting mode)大涡理想性试验,验证了新方案中气溶胶对数正态谱函数中数浓度、几何半径和标准差3个参量对云滴谱演变的影响。针对3个参量的敏感性试验表明新的气溶胶活化方案和三参数云滴凝结增长方案能够描述气溶胶谱对云滴谱演变的影响规律:气溶胶数浓度对云滴谱影响最显著,数浓度越高活化生成的云滴数量越多,云滴半径越小,云滴谱趋向窄谱,气溶胶数浓度低时,云滴数量少、半径大。较大的几何半径使气溶胶谱向大粒径移动,导致大云滴生成,标准差对云滴谱的影响最不显著。
文摘To discuss the effects of pesticide viscosity on the atomisation characteristics of an agricultural nozzle, glycerite with different mass fractions was prepared to replace the pesticide. First, the atomisation region of the nozzle was meshed and sized. Second, the speed and kinetic energy of the droplets at different positions in the atomisation region were measured by Phase Doppler Anemometry. The results demonstrated that the Sauter mean diameter, volume mean diameter and arithmetic mean diameter of droplets first decreased and then increased gradually in the axial direction of the atomisation region. Surface waves of a certain pattern were formed on the liquid surface, which was ejected by the disturbance of external air resistance. As the distance increased, the amplitude increased and the wave crest was broken into small droplets. These droplets then collided and agglomerated into large droplets under the effect of gravity. Droplets had an approximately symmetric distribution on the radial direction of the atomisation region, and the droplets were small in the middle and large at the two ends. The droplet size was positively related to the radial distance. Compared with the droplet speed at the two ends, the droplet speed at the axis was higher and the droplet size was smaller. Moreover, the kinetic energy of the droplets along the axial direction decreased sharply and then increased slowly. Droplets with high viscosity at the near end of the nozzle had small kinetic energy, and the effects of liquid viscosity on the atomisation characteristics of a nozzle could not be neglected. The droplet kinetic energy slightly increased at the far end.
