摘要
以三苯乙烯基苯酚聚氧乙烯醚TSPOE-n[n代表环氧乙烷(EO)数,为13、16、20、29]为反应物,氨基磺酸为硫酸化试剂,尿素为催化剂,合成了一系列三苯乙烯基苯酚聚氧乙烯醚硫酸酯盐(TSPOES-n)。利用TSPOES-n为分散剂制备了液体分散染料,通过粒径分析探究了液体分散染料的储存稳定性,优选储存稳定性好的液体分散染料研究了其染色性能。结果表明,TSPOE-n与氨基磺酸物质的量比为1∶1.6时,阴离子活性物(TSPOES-n)含量均在85%以上。分散剂TSPOES-n中随着n增大,制备的液体分散染料粒径和多分散指数(PDI)呈先降低后增大趋势。由分散剂TSPOES-20制备的液体分散染料粒径为165.9nm、PDI为0.195,储存稳定性较好。将其用于高温(130℃)染色时,染色匀染性好,染色后织物无需还原清洗耐摩擦色牢度仍达4~5级,且染后残液化学需氧量远低于粉体分散染料。
A series of tristyrylphenol polyoxyethylene ether sulfate salts[TSPOES-n,n represents the number of ethylene oxide(EO),n=13,16,20,29]were synthesized using tristyrylphenol ethoxylates(TSPOE-n)as reactant,sulfamic acid as sulphating reagent and urea as catalyst.Liquid disperse dyes were prepared using TSPOES-n as dispersant,the storage stability of liquid disperse dyes was evaluated by particle size analysis,and the dyeing properties of liquid disperse dye with good storage stability were investigated.The results showed that the content of anionic active substances(TSPOES-n)was above 85%when the molar ratio of TSPOE-n to sulfamic acid was 1∶1.6.With increasing of EO number of dispersant TSPOES-n,the particle size and particle size polydispersity index(PDI)of prepared liquid disperse dye decreased first and then increased.The liquid disperse dye prepared by dispersant TSPOES-20 had a particle size of 165.9 nm and PDI of 0.195,and exhibited the best storage stability.When it was used for dyeing at high-temperature(130℃),the dyed fabric had good dyeing levelness property,its color fastness to rubbing could still reach 4~5 grades after dyeing without reduction cleaning,and the chemical oxygen demand of residual liquid was much lower than that of powder disperse dye.
作者
孙洋洋
姜建堂
田妮妮
沈一峰
倪华钢
SUN Yangyang;JIANG Jiantang;TIAN Nini;SHEN Yifeng;NI Huagang(College of Textile Science and Engineering(International Institute of Silk),Zhejiang Sci-Tech University,Hangzhou 310018,Zhejiang,China;Engineering Research Center for Eco-Dyeing and Finishing of Textiles,Ministry of Education,Hangzhou 310018,Zhejiang,China;Key Laboratory of Advanced Textile Materials and Manufacturing Technology,Ministry of Education,Hangzhou 310018,Zhejiang,China;School of Science,Zhejiang Sci-Tech University,Hangzhou 310018,Zhejiang,China)
出处
《精细化工》
EI
CAS
CSCD
北大核心
2022年第6期1263-1269,共7页
Fine Chemicals
基金
浙江省教育厅科研项目(Y202147803)。
关键词
三苯乙烯基苯酚聚氧乙烯醚硫酸酯盐
液体分散染料
粒径
匀染性
纺织染整助剂
tristyrylphenol polyoxyethylene ether sulfate salts
liquid disperse dyes
particle size
dyeing levelness
dyeing and finishing auxiliaries
