摘要
氨吹脱是一种对养殖场沼液进行深度处理和氮回收的技术,利用沼气对沼液进行氨吹脱可通过沼气反复循环吹脱实现沼气提纯和沼液氨氮脱除耦合,是氨吹脱的新型研究方向,但目前缺乏相关工艺参数。基于此,该文利用CH_4和CO_2混合气体模拟沼气,研究了吹脱温度(70、80、90℃)和气体中CO_2比例(10%、20%、40%)对沼液氨氮脱除过程参数和氨氮脱除效果的影响。结果表明:在试验条件下,温度较高,CO_2比例较低时沼液氨氮脱除效果较好。在90℃、吹脱气体中CO_2比例为10%时,吹脱6 h后沼液的最终氨氮去除率达到99.28%,出水氨氮质量浓度低于60 mg/L,且在40min内沼液的氨氮去除率达到92.15%,反应动力学常数为1.034h-1,可依靠脱除沼液中的酸性物质使得沼液的pH值上升至9.92。对吹脱后沼液水质分析表明,利用模拟沼气对沼液进行氨吹脱,沼液中的化学需氧量(chemicaloxygen demand,COD)去除率达到23.53%～42.20%,总磷(total phosphorus, TP)去除率达到15.85%～32.97%,浊度去除率为20.79%～29.74%。研究结果为利用富CO_2气体对沼液进行氨吹脱工艺提供参考。
Ammonia stripping is an effective treatment technology for recovery of nitrogen from the anaerobic digestate(biogas slurry).Biogas stripping of ammonia from anaerobic digestate can realize biogas purification and ammonia removal coupling through recycled of biogas,which is a new research direction of ammonia stripping.However,the main difficulty is that the ammonia stripping performance is negatively correlated to the CO2 ratio in the stripping gas.In this study,the effect of temperature(70、80、90℃)and the ratio of CO2(10%、20%、40%)in biogas on the removal efficiency of ammonia were studied.The ammonia removal rate(η)and kinetics constant(k)were adopted to evaluate the ammonia removal performance.The results indicated that the ammonia removal rate from the biogas slurry were 96.81%、98.65%、99.28%,respectively at 70℃,80℃and 90℃when the ratio of CO2 in the stripping gas was 10%,and ammonia concentration was lower than 60 mg/L after biogas slurry stripping.The ammonia removal rates were 72.81%、84.00%and 88.39%,respectively at 70℃,80℃and 90℃when the ratio of CO2 in stripping gas was 20%.While CO2 ratio in stripping gas reached 40%,the ammonia removal rate were 62.94%、75.23%and 83.29%,respectively at different stripping temperatures.As the temperature of stripping gas increase,the ammonia nitrogen rate increased,however as the ratio of CO2 in the stripping gas increase,the ammonia removal rate decreased.Increase of temperature is beneficial to reduce inhibitory effect of CO2 on ammonia removal efficiency in biogas.And the ammonia removal rate of biogas slurry reached 90%within 40 min at 90℃while the maximum removal rate of ammonia were close to 2 h and 3 h at 80℃and 70℃,respectively.Ammonia stripping can raised pH value to above 8.6 relying on the removal of acidic substances in the biogas slurry by mixed gas of CH4 and CO2.Theoretical maximum ammonia removal rate in biogas slurry can be calculated according to the maximum pH value in biogas slurry during the ammonia stripping process
作者
艾平
彭靖靖
席江
张秀之
汤炜
张如峰
梅自力
Ai Ping;Peng Jingjing;Xi Jiang;Zhang Xiuzhi;Tang Wei;Zhang Rufeng;Mei Zili(College of Engineering,Huazhong Agricultural University,Wuhan 430070,China;Key Laboratory of Development andApplication of Rural Renewable Energy,Ministry of Agriculture and Rural Affairs,Chengdu 610041,China)
出处
《农业工程学报》
EI
CAS
CSCD
北大核心
2019年第1期206-212,共7页
Transactions of the Chinese Society of Agricultural Engineering
基金
国家自然科学基金(51406064)
湖北省自然科学基金(2018CFB512)
关键词
沼液
温度
PH值
氨吹脱
CO2负荷
biogas slurry
temperature
pH value
ammonia stripping
CO2 loading
