摘要
为明晰气爆技术对土壤的深松效果,采用剖面法观测土体裂隙及扰动情况,设计正交试验分析气爆参数对土体裂隙扩展的影响,建立了气爆土体裂隙迹线方程及土体扰动模型,讨论了土体破坏形式对松土效果的影响,结果表明:气爆深度小于25 cm时,土体以张拉破坏为主,气爆起劈力为0.17 MPa,土面易抬升,裂隙中心为气爆中心,裂隙扩展随气压增大而增大,土体扰动系数为50%;气爆深度大于25 cm时,土体以剪切破坏为主,气爆起劈力为0.39 MPa,土面抬升不明显,土体裂隙中心下移,且下移量随气压增大而增大,土体扰动系数大于50%,松土效果优于张拉破坏;气爆深度为30 cm、气爆压力为1 MPa左右较适宜。该研究可为气爆松土参数优化提供参考。
Soil subsoiling is currently the most widely used method for soil loosening,which can break the hard bottom of soil.At present,soil subsoiling operations mainly use shovel subsoiler,which has common problems like poor subsoiling effect,uneven soil disturbance and high energy consumption.In this context,a new subsoiling technology,gas explosion subsoiling,is studied in this paper,which injects high pressure gas into the soil to cause fissures,thereby breaking the bottom soil and achieving the purpose of subsoiling.In order to clarify the subsoiling effect of gas explosion on soil,an orthogonal test with the gas explosion parameters like pressure,depth and volume was designed.The soil block used in test was in standard size of 100 cm×50 cm(diameter×height).The soil fissures and disturbance situation on the soil section were observed through the cross-sectional treatment method,and the influence of gas explosion parameters on soil fissure extension was analyzed.Then,the soil fissure trace equation and soil disturbance model were established based on the 9 orthogonal test results calculated by OriginPro software and Auto2Fit software.The effect of soil damage form on the impact of soil subsoiling was discussed based on Mohr-Coulomb soil strength theory and Rankine’s earth pressure theory.The orthogonal experiment results showed that the greater the gas explosion pressure,the deeper the gas explosion depth;the more the gas volume,the better the soil subsoiling effect.The soil fissure trace equation was a quadratic function and the soil disturbance area was parabolic.This research provided a model and method for studying the soil fissure trace equation,and the soil hardness in the equation could be used as a variable for the soil type,so the soil fissure trace equation was applicable to most types of soils.The soil was mainly subjected to pulling damage when the gas explosion depth was less than 25 cm,the soil surface tended to rise at the gas splitting force of 0.17 MPa and the disturbance coefficient of 50%,and t
作者
奚小波
张瑞宏
单翔
叶伟伟
史扬杰
马国梁
陶德清
Xi Xiaobo;Zhang Ruihong;Shan Xiang;Ye Weiwei;Shi Yangjie;Ma Guoliang;Tao Deqing(College of Mechanical Engineering,Yangzhou University,Yangzhou 225127,China;School of Hydraulic Energy and Power Engineering,Yangzhou University,Yangzhou 225127,China;Jiangsu Agri-animal Husbandry Vocational College,Taizhou 225300,China)
出处
《农业工程学报》
EI
CAS
CSCD
北大核心
2018年第6期15-24,共10页
Transactions of the Chinese Society of Agricultural Engineering
基金
国家重点研发计划(2016YFD0700903)
江苏省农机三新工程项目(NJ2017-11)
关键词
土壤
模型
孔隙度
气爆松土
气压劈裂
土体裂隙
土体扰动系数
土体截面
soils
models
porosity
gas explosion subsoiling
pneumatic fracturing
soil fissure
soil disturbance coefficient
soil section
