It is difficult to obtain in vivo digestion kinetics data of high protein ingredients using chickens. Collecting kinetics data requires repeated sampling of digesta from the small intestine during the digestion proces...It is difficult to obtain in vivo digestion kinetics data of high protein ingredients using chickens. Collecting kinetics data requires repeated sampling of digesta from the small intestine during the digestion process,which is not easily accomplished due to the anatomical structure of chicken digestive tract. An in vitro technique is proposed for measuring the digestion kinetics of protein sources fed to chickens. The method has a 30 min gastric and 3 h intestinal phase. Five hundred milligram crude protein(CP)equivalent of each meal sample(CP = % N × 6.25) was digested with pepsin(28,260 units) in 50 m L polyethylene centrifuge tubes for 30 min in a shaking water bath(150 strokes/min; 30 mm stroke length)at 41C. The 6.5 mL pancreatin was selected as the enzyme concentration for the intestinal phase, during which time 500 m L aliquots were collected at 0, 15, 30, 45, 60, 90, 120, 150, 180 and 240 min. Samples were diluted 1:820 with HCl and sodium acetate buffer, and then mixed with ninhydrin reagent(2:1) at100 ± 2C for 15 min and spectrometric readings taken at 568 nm. To validate the assay, 5 replications of soybean meal(SBM), corn gluten meal(CGM), corn distillers dried grains with solubles(CDDGS), porcine meal(PCM), fish meal(FM) and casein(CA) were digested. The digestion data were modeled with PROC NLIN procedure, and the intra coefficient of variation(CV) assessed using PROC MEANS of SAS 9.4. The digestion values at 180 min were SBM 95 ± 4, FM 93 ± 3, PCM 68 ± 4, CGM 82 ± 3 and CDDGS 70 ± 2.Intra CV for SBM, CGM, CDDGS, PCM and FM were 5%, 5%, 12%, 10% and 2%, respectively. The estimated fractional digestion rates for SBM, CGM, CDDGS, FM and PCM were 0.023, 0.013, 0.009, 0.024 and 0.013,respectively. In conclusion, the proposed in vitro technique estimated the rate and extent of the digestion of CP for the meals with low intra CV.展开更多
This study was carried out to determine the effect of replacement of forage fiber sources from alfalfa and Leymus chinensis with nonforage fiber sources（NFFS） from dried distillers grains with solubles and corn germ...This study was carried out to determine the effect of replacement of forage fiber sources from alfalfa and Leymus chinensis with nonforage fiber sources（NFFS） from dried distillers grains with solubles and corn germ meal on calves growth, rumen development and blood parameters. 48 female and 12 male calves（（110.55±15.36） kg of body weight and 12 wk of age） were assigned randomly to four dietary treatments（15 calves/treatment） in a completely randomized design. Experimental diets were： 0% NFFS（control）, 9% NFFS（group 1）, 18% NFFS（group 2）, 27% NFFS（group 3）, and contained equivalent neutral detergent fiber and total digestible nutrients, respectively. The dry matter intake was similar among diets, averaging 3.33 kg d-1, and no differences were detected for body weight, withers height, body length and heart girth. In addition, the development of rumen, reticulum, omasum and abomasum also were similar among diets. Dry matter, crude protein, and neutral detergent fiber digestibilities increased with the increasing levels of NFFS in the experimental diets, but had no significant effect. Blood urea nitrogen, total protein and glubulin were not affected by the dietary treatment, but group 3 resulted in the highest（P〈0.05） concentrations of glucose and the lowest（P〈0.05） concentrations of triglycerides and albumin. In conclusion, dried distillers grains with solubles（DDGS） and corn germ meal（CGM） were available and alternative fiber sources for Holstein calf diets.展开更多
Background： This study was conducted to evaluate the apparent metabolizable energy （AME） and true metabolizable energy （TME） contents in 30 sources of corn distillers dried grains with solubles （DDGS） in adult ...Background： This study was conducted to evaluate the apparent metabolizable energy （AME） and true metabolizable energy （TME） contents in 30 sources of corn distillers dried grains with solubles （DDGS） in adult roosters, and establish the prediction equations to estimate the AME and TME value based on its chemical composition and color score. Methods： Twenty-eight sources of corn DDGS made from several processing plants in 11 provinces of China and others imported from the United States. DDGS were analyzed for their metabolizable energy （ME） contents, measured for color score and chemical composition （crude protein, crude fat, ash, neutral detergent fiber, acid detergent fiber）, to predict the equation of ME in DDGS. A precision-fed rooster assay was used, each DDGS sample was tube fed （50 g） to adult roosters. The experiment was conducted as a randomized incomplete block design with 3 periods. Ninety-five adult roosters were used in each period, with 90 being fed the DDGS samples and 5 being fasted to estimate basal endogenous energy losses. Results： Results showed that the AME ranged from 5.93 to 12.19 MJ/kg, TME ranged from 7.28 to 13.54 MJ/kg. Correlations were found between ME and ash content （-0.64, P 〈 0.0]） and between ME and yellowness score （0.39, P 〈 0.05） of the DDGS samples. Furthermore, the best-fit regression equation for AME content of DDGS based on chemical composition and color score was AME = 6.57111 ＋ 0.5]475 GE - 0.10003 NDF ＋ 0.1 3380 ADF ＋ 0.07057 fat - 0.57029 ash - 0.02437 L （R^2 = 0.70）. The best-fit regression equation for TME content of DDGS was TME = 7.92283 ＋ 0.51475 GE - 0.10003 NDF ＋ 0.13380 ADF ＋ 0.07057 fat - 0.57029 ash - 0.02437 L （R2 = 0.70）. Conclusions： This experiment suggested that measuring the chemical composition and color score of a corn DDGS sample may provide a quality parameter for identifying corn DDGS sources energy digestibility and metabolizable energy content.展开更多
Corn distillers dried grains with solubles(DDGS) is a co-product of the fuel ethanol industry that is an excellent source of energy, digestible amino acids, and digestible phosphorus. However, the antioxidant capacity...Corn distillers dried grains with solubles(DDGS) is a co-product of the fuel ethanol industry that is an excellent source of energy, digestible amino acids, and digestible phosphorus. However, the antioxidant capacity and phytochemical content of DDGS and how it is influenced by production parameters is unknown. Therefore, 16 DDGS samples obtained from different ethanol production plants in the U.S.were characterized for antioxidant capacity, vitamin E, xanthophylls, and ferulic acid content and compared with corn. The antioxidant capacity of DDGS samples, measured using the 2,2-diphenyl-lpicrylhydrazyl(DPPH) assay, varied almost 2 folds among samples, but in all cases was more than 3 times that of corn. All DDGS samples had a considerably greater concentration of tocopherols and tocotrienols(lipid-soluble antioxidants) than corn. However, the relative concentrations among the tocopherols and tocotrienols tended to be similar to corn. The xanthophyll lutein was present in all DDGS samples and in all cases exceeded the content in corn. Zeaxanthin was detected in most samples. The total ferulic acid content of the DDGS samples was almost 3-fold greater than corn, but, as in corn, almost all was present in a bound form. However, the concentration of unbound(free) ferulic acid was more than 3 times the concentration found in the corn sample. Thus, DDGS is a rich source of phytochemical compounds and may provide antioxidant and health benefits beyond its macronutrient composition. However, differences in processing can greatly influence the phytochemical content and quality of DDGS. In particular,thermal abuse due to excessive heat used in drying may lead to lipid oxidation products that may have deleterious effects when incorporated into feeds.展开更多
The primary objective of this experiment was to determine the effects of heat treatment on the standardized ileal digestibility （SID） of amino acids （AA） in corn distillers dried grains with solubles （DDGS） fed ...The primary objective of this experiment was to determine the effects of heat treatment on the standardized ileal digestibility （SID） of amino acids （AA） in corn distillers dried grains with solubles （DDGS） fed to growing pigs. The second objective was to develop regression equations that may be used to predict the concentration of SID AA in corn DDGS. A source of corn DDGS was divided into 4 batches that were either not autoclaved or autoclaved at 130℃ for 10, 20, or 30 min. Four diets containing DDGS from each of the 4 batches were formulated with DDGS being the only source of AA and CP in the diets. A N-free diet also was formulated and used to determine the basal endogenous losses of CP and AA. Ten growing pigs （initial BW： 53.5 ＋ 3.9 kg） were surgically equipped with a T-cannula in the distal ileum and allotted to a replicated 5 x4 Youden square design with 5 diets and 4 periods in each square. The SID of CP decreased linearly （P〈 0.05） from 77.9% in non-autoclaved DDGS to 72.1, 66.1, and 68.5% in the DDGS samples that were autoclaved for 10, 20, or 30 min, respectively. The SID of lysine was quadratically reduced （P〈 0.05） from 66.8% in the non-autoclaved DDGS to 54.9, 55.3, and 51.9% in the DDGS autoclaved for 10, 20, or 30 min, respectively. The concentrations of SID Arginine, Histidine, Leucine, Lysine, Methionine, Phenylalanine, or Threonine may be best predicted by equations that include the concentration of acid detergent insoluble N in the model （r2 = 0.76, 0.68, 0.67, 0.84, 0.76, 0.73, or 0.54, respectively）. The concentrations of SID Isoleucine and Valine were predicted （r2 = 0.58 and 0.54, respectively） by the Lysine：CP ratio, whereas the concentration of SID Tryptophan was predicted （r2 = 0.70） by the analyzed concentration of Tryptophan in DDGS. In conclusion, the SID of AA is decreased as a result of heat damage and the concentration of SID AA in heat-damaged DDGS may be predicted by regression equations developed in this experiment.展开更多
Background： Post-production fractionation of wheat distillers grains with solubles（DDGS） increases their crude protein content and reduces their fiber content.This experiment was conducted to determine the effects ...Background： Post-production fractionation of wheat distillers grains with solubles（DDGS） increases their crude protein content and reduces their fiber content.This experiment was conducted to determine the effects of fractionation of wheat DDGS on apparent total tract digestibility（ATTD） and performance when fed to broiler chicks（0–21 d）.Methods： A total of 150,day-old,male broiler chicks（Ross-308 line;Lilydale Hatchery,Wynyard,Saskatchewan） weighing an average of 49.6 ± 0.8 g were assigned to one of five dietary treatments in a completely randomized design.The control diet was based on wheat and soybean meal and contained 20% regular wheat DDGS.The experimental diets contained 5,10,15 or 20% fractionated wheat DDGS added at the expense of regular wheat DDGS.Results： The ATTD of dry matter and gross energy were linearly increased（P 0.01） as the level of fractionated wheat DDGS in the diet increased.Nitrogen retention was unaffected by level of fractionated wheat DDGS（P 0.05）.Weight gain increased linearly（P = 0.05） as the level of fractionated wheat DDGS in the diet increased.Feed intake,feed conversion and mortality were unaffected by level of fractionated wheat DDGS in the diet（P 0.05）.Conclusions： Post-production fractionation of wheat DDGS improves their nutritional value by lowering their fiber content and increasing their content of crude protein and energy.These changes in chemical composition supported increased weight gain of broilers fed wheat DDGS.展开更多
The objective of this experiment was to determine the standardized ileal digestibility（SID） of amino acids（AA） in 3sources of distillers dried grains with solubles（DDGS） with different concentrations of fat.Twel...The objective of this experiment was to determine the standardized ileal digestibility（SID） of amino acids（AA） in 3sources of distillers dried grains with solubles（DDGS） with different concentrations of fat.Twelve growing barrows（initial body weight：76.1 ± 6.2 kg） were randomly allotted to a replicated 6×4 Youden square design with 6 diets and 4 periods.The fat content of the 3 sources of DDGS were 11.5,7.5,and 6.9%respectively.Diets contained 60%DDGS and fat concentration of the diets were 7.5,52,and 5.2%,respectively.Two additional diets containing the 2sources of DDGS with 75 and 6.9%fat were also formulated,and corn oil was added to these diets to increase the concentration of fat in the diets to levels that were calculated to be similar to the diet containing conventional DDGS with 11.5%fat.A N-free diet was also formulated to calculate endogenous losses of crude protein（CP） and AA from the pigs.Pigs were fed experimental diets during four 7-d periods.The first 5 d of each period were an adaptation period and ileal digesta were collected on d 6 and 7 of each period.The apparent ileal digestibililty（AID） and SID of CP and all indispensable AA,except AID Pro and SID of Trp,were greater（P 〈 0.01） in conventional DDGS than in the 2 sources of DDGS with reduced fat.Adding oil to the diets containing the 2 sources of DDGS with reduced fat did not consistently increase SID of AA.In conclusion,conventional DDGS has greater SID values for most AA compared with DDGS that contains less fat and inclusion of additional oil to diets containing low-fat DDGS does not increase AID or SID of AA.The lower AA digestibility in low-fat DDGS could not be overcome by the inclusion of additional fat to the diets.展开更多
Soy molasses and soy solubles are byproducts of the conventional soy protein concentrate and soy protein isolate manufacturing processes,respectively.Conversion of the carbohydrates in these byproducts into ethanol wa...Soy molasses and soy solubles are byproducts of the conventional soy protein concentrate and soy protein isolate manufacturing processes,respectively.Conversion of the carbohydrates in these byproducts into ethanol was examined.Standardized amounts of commercial cellulase enzymes(Novozyme cellulase,β-glucosidase,and pectinase)were added to soy molasses and soy solubles solutions prepared at various solid loading rates(33%,50%,60%,75%,and 80%)to hydrolyze oligosaccharides,followed by fermentation for 96 h using Saccharomyces cerevisiae NRRL Y-2034 and Scheffersomyces stipitis NRRL Y-7124.Ethanol-extracted soybean meal(SBM)carbohydrates were also fermented for 96 h without enzymes.S.cerevisiae and S.stipitis produced about 12.5-45.0 g/L and 6.0-28.0 g/L ethanol,respectively,on molasses and solubles across these solid loading rates.The S.stipitis produced about 6.5-17 g/L ethanol and S.cerevisiae produced about 6.5-22 g/L ethanol on ethanol-extracted carbohydrates.展开更多
This trial was conducted to determine the effects of graded levels of wheat distillers dried grains with solubles （DDGS） on nutrient digestibility, performance and carcass characteristics of pigs （21.8 to 112.3 kg...This trial was conducted to determine the effects of graded levels of wheat distillers dried grains with solubles （DDGS） on nutrient digestibility, performance and carcass characteristics of pigs （21.8 to 112.3 kg） fed diets based on wheat and field peas. Forty crossbred pigs were assigned on the basis of sex and weight to one of five dietary treatments in a 5 x 2 （treatment x sex） factorial arrangement. The experimental diets were based on wheat and field peas and were formulated to contain 0, 4.86%, 9.71%, 14.57% or 19.42% wheat DDGS during the growing period and 0, 4.01%, 8.05%, 12.10% and 16.14% wheat DDGS during the finishing period. At the highest levels, ~vheat DDGS supplied 100% of the supplementary protein. The digestibility coefficient for gross energy showed a tendency towards a linear decline （P 〈 0.08 ） as the level of wheat DDGS in the diet increased while digestibility coefficients for dry matter and crude protein were unaffected （P 〉 0. 05 ） by inclusion level of wheat DDGS. During the growing period （21.8 to 60.8 kg）, weight gain of pigs fed wheat DDGS declined （P〈0.01） linearly. The impairment in growth appeared to be associated with a decrease in feed in- take which also declined linearly （P 〈 0.01 ） with increasing inclusion level of wheat DDGS. Feed conversion was unaffected by level of wheat DDGS. During the finishing period （60.8 to 112.3 kg）, and over the entire experimental period （21.8 to 112.3 kg ）, weight gain and feed conversion declined linearly as the dietary inclusion level of wheat DDGS increased. Carcass traits were generally unaffected by the inclusion of wheat DDGS with the exception of a trend towards a linear （P = 0.10） reduction in lean yield and a linear increase （ P = 0.09） in loin fat as the level of wheat DDGS in the diet increased. Overall, these results suggest that wheat DDGS are inferior to field peas as a supplementary protein source for use in swine rations.展开更多
Distillers dried grains with solubles (DDGS) in combination with soy protein concentrate (SPC) with and without an essential amino acid (EAA) complex were assessed as protein alternatives in juvenile Yellow Perch Perc...Distillers dried grains with solubles (DDGS) in combination with soy protein concentrate (SPC) with and without an essential amino acid (EAA) complex were assessed as protein alternatives in juvenile Yellow Perch Perca flavescens diets. Diets contained 5% FM, 40% SPC, and 20% or 40% DDGS each with or without EAA. No mortalities or health assessment differences were observed during the trial and all fish readily accepted the experimental diets. Diets supplemented with EAA produced greater weight gain, improved feed conversion, and apparent protein digestibility. Performance was consistently improved for fish fed diets containing amino acid supplements. Based on these results, Yellow Perch are able to utilize high levels of the plant proteins, accompanied with EAAs, as a FM replacer.展开更多
Background： The immense growth in global bioethanol production has greatly increased the supply of by-products such as whole stillage and condensed distiller＇s solubles, which could be potentially used for animal fe...Background： The immense growth in global bioethanol production has greatly increased the supply of by-products such as whole stillage and condensed distiller＇s solubles, which could be potentially used for animal feeding. The objective of this study was to investigate effects of liquid feeding high levels of corn condensed distiller＇s solubles（CCDS） and whole stillage（CWS） on growth performance, carcass characteristics, belly firmness and meat sensory traits of pigs.Methods： A total of 256 pigs were blocked by sex and initial BW（13.5 ± 2.5 kg）, and pens of pigs（8 pigs/pen） were randomly allocated to 1 of 4 dietary treatments（8 pens/treatment）： 1） corn-soybean meal based diet as control, 2） 25%CWS ＋ 5% CCDS, 3） 19.5% CWS ＋ 10.5% CCDS, and 4） 19.5, 26, and 32.5% CWS ＋ 10.5, 14, and 17.5% CCDS in phases 1（28 d）, 2（38 d）, and 3（60 d）, respectively. Inclusion levels of CCDS and CWS for Treatments 1, 2, and 3 were fixed during all the three phases of the experiment. Inclusion levels of CWS and CCDS were on 88% dry matter basis. The liquid feeding system delivered feed from the mixing tank to feed troughs by high-pressure air, had sensors inside feed troughs, and recorded daily feed intake on the basis of a reference feed intake curve. The pigs were fed 5 to 10 times per day with increasing frequency during the experiment.Results： Control pigs had greater（P 0.10） dressing percentage, loin muscle depth, and lean percentage were observed among the four treatments. Inclusion of CWS and CCDS reduced（P 0.10） the overall like,flavor, tenderness and juiciness of loin chops when compared with the control group.Conclusion： In conclusion, our results indicate that including 30–50% of a mixture of whole stillage and condensed distiller＇s solubles in the growing-finishing diets may reduce growth performance, carcass weight and belly firmness, but does not affect pork sensory traits.展开更多
Pseudomonas putida KT217 was grown on a complex medium comprised of co-products of the ethanol and biodiesel industries to assess the organism's capability to produce medium-chain-length polyhydroxyalkanoate (mcl-...Pseudomonas putida KT217 was grown on a complex medium comprised of co-products of the ethanol and biodiesel industries to assess the organism's capability to produce medium-chain-length polyhydroxyalkanoate (mcl-PHA). The growth phase was carried out in a medium containing 400 g/L condensed corn solubles (CCS), supplemented with ammonium hydroxide as a nitrogen source. Following the exponential phase, co-products of the biodiesel industry (soapstock and glycerin) were fed into the reactor to trigger PHA production. When glycerin was added to the bioreactor (75 g/L total addition), the final cell dry weight (CDW) and PHA content were 30 g/L and 31%, respectively. The monomeric composition in the PHA formed was relatively uniform throughout incubation with 3-hydroxydecanoate dominating. When a total of 153 g/L of sunflower soapstock was added to the bioreactor in a fed-batch manner, the final CDW and PHA content were 17 g/L and 17%, respectively. Following addition of soapstock the monomeric composition of the polymer changed dramatically, with the 3-hydroxyoctanoate monomer becoming dominant and greater unsaturation present in the PHA.展开更多
Background:Diet has a profound impact on the rumen microbiota,and the impact can vary among the different rumen ecological niches(REN).This study investigated the effects of dietary replacement of soybean meal(SBM)wit...Background:Diet has a profound impact on the rumen microbiota,and the impact can vary among the different rumen ecological niches(REN).This study investigated the effects of dietary replacement of soybean meal(SBM)with dried distillers grains with solubles(DDGS)on the rumen microbiota occupying different REN of growing Hu lambs.After a 9-week feeding trial,6 lambs from each dietary treatment(SBM vs.DDGS-based diets)were slaughtered for sample collection.The microbiota of the rumen solid,liquid,and epithelium fractions was examined using amplicon sequencing analysis of bacterial 16S rRNA gene,functional prediction,and qPCR.Results:No interaction of dietary protein source(PS)and REN were detected for virtually all the measurements made in this study.The DDGS substitution resulted in very limited influence on bacterial community structure.However,the metabolic pathways predicted from 16S rRNA gene sequences varied greatly between SBM-and DDGS-based diets.The populations of rumen total bacteria,fungi,sulfate-reducing bacteria(SRB),and methanogens were not influenced by DDGS substitution,but the population of protozoa was reduced.The bacterial communities in rumen solid(RS)and liquid(RL)were similar in taxonomic composition but were different in relative abundance of some taxa.In contrast,the bacterial composition and relative abundance of rumen epithelium(RE)were greatly distinct from those of the RS and the RL.In alignment with the bacterial relative abundance,the metabolic pathways predicted from 16S rRNA genes also varied greatly among the different REN.The populations of total bacteria,protozoa,and methanogens attached to the RE were smaller than those in the RS and RL,and the fungal population on the rumen epitheliumwas smaller than that in the RS but similar to that in the RL.On the contrary,the SRB population on the RE was greater than that in the RS and RL.Conclusions:Substitution of SBM with DDGS had greater impact to the protozoa than to the other microbes,and the microbial community structure and functions展开更多
Scleroglucan is an extracellular polysaccharide produced by the fungi Sclerotium.Scleroglucan is stable over a broad range of temperatures,pH and salt concentration,thus having great potential in many diverse applicat...Scleroglucan is an extracellular polysaccharide produced by the fungi Sclerotium.Scleroglucan is stable over a broad range of temperatures,pH and salt concentration,thus having great potential in many diverse applications.Common media for scleroglucan production contain expensive components,such as yeast extract,that make the medium cost-ineffective for some industrial applications.Thus we developed a medium which uses Condensed Corn Solubles(CCS),a nutrient-rich byproduct of corn-based ethanol production,to replace expensive components.Methods typically used to recover scleroglucan are also expensive,and can limit commercialization.To evaluate alternative processes for scleroglucan recovery,we prepared scleroglucan in a modified version of Wang’s medium and a CCS-glucose medium.Broth samples were initially subjected to the standard recovery method to develop a complete mass balance,and then we evaluated various treatments to improve scleroglucan recovery.These included heat treatments to lyse cells,using different alcohol precipitants,freezing or refrigerating before recovery,and diluting broth to enhance cell separation.The CCS medium produced 14.2 g/L scleroglucan,compared to 10.1 g/L in the modified Wang’s medium.Based on the standard recovery protocol,we determined that 96%of the scleroglucan was recovered from the initial centrifugation and precipitation.Washing the cell pellet with water and recentrifuging only recovered a minimal amount of scleroglucan,and thus it could be eliminated from protocol to save energy and costs.Lysing cells by boiling or autoclaving did not release more scleroglucan than un-heated samples,and we also found no statistical difference between ethanol,isopopanol,and methanol as scleroglucan precipitants.Refrigerating the broth prior to scleroglucan recovery had no significant effect,while freezing actually decreased scleroglucan recovery.Initially diluting the broth by 0.50 or 0.34 resulted in the greatest scleroglucan recovery,while higher or lower dilutions decreased recovery展开更多
基金the National Science and Engineering Research Council(NSERC)Industrial Research Chair Program for financial support for this project(Grant No.IRCSA452664-12)+10 种基金Funding for this program was derived from AviagenCanadian Poultry Research CouncilChicken Farmers of SaskatchewanNSERCOntario Poultry Industry CouncilPrairie Pride Natural Foods Ltd.Saskatchewan Egg ProducersSaskatchewan Hatching Egg ProducersSaskatchewan Turkey ProducersSofina Foods Inc.the University of Saskatchewan
文摘It is difficult to obtain in vivo digestion kinetics data of high protein ingredients using chickens. Collecting kinetics data requires repeated sampling of digesta from the small intestine during the digestion process,which is not easily accomplished due to the anatomical structure of chicken digestive tract. An in vitro technique is proposed for measuring the digestion kinetics of protein sources fed to chickens. The method has a 30 min gastric and 3 h intestinal phase. Five hundred milligram crude protein(CP)equivalent of each meal sample(CP = % N × 6.25) was digested with pepsin(28,260 units) in 50 m L polyethylene centrifuge tubes for 30 min in a shaking water bath(150 strokes/min; 30 mm stroke length)at 41C. The 6.5 mL pancreatin was selected as the enzyme concentration for the intestinal phase, during which time 500 m L aliquots were collected at 0, 15, 30, 45, 60, 90, 120, 150, 180 and 240 min. Samples were diluted 1:820 with HCl and sodium acetate buffer, and then mixed with ninhydrin reagent(2:1) at100 ± 2C for 15 min and spectrometric readings taken at 568 nm. To validate the assay, 5 replications of soybean meal(SBM), corn gluten meal(CGM), corn distillers dried grains with solubles(CDDGS), porcine meal(PCM), fish meal(FM) and casein(CA) were digested. The digestion data were modeled with PROC NLIN procedure, and the intra coefficient of variation(CV) assessed using PROC MEANS of SAS 9.4. The digestion values at 180 min were SBM 95 ± 4, FM 93 ± 3, PCM 68 ± 4, CGM 82 ± 3 and CDDGS 70 ± 2.Intra CV for SBM, CGM, CDDGS, PCM and FM were 5%, 5%, 12%, 10% and 2%, respectively. The estimated fractional digestion rates for SBM, CGM, CDDGS, FM and PCM were 0.023, 0.013, 0.009, 0.024 and 0.013,respectively. In conclusion, the proposed in vitro technique estimated the rate and extent of the digestion of CP for the meals with low intra CV.
基金supported by the National Key Technologies during the 12th Five-Year Plan period (2011BAD17B03)
文摘This study was carried out to determine the effect of replacement of forage fiber sources from alfalfa and Leymus chinensis with nonforage fiber sources（NFFS） from dried distillers grains with solubles and corn germ meal on calves growth, rumen development and blood parameters. 48 female and 12 male calves（（110.55±15.36） kg of body weight and 12 wk of age） were assigned randomly to four dietary treatments（15 calves/treatment） in a completely randomized design. Experimental diets were： 0% NFFS（control）, 9% NFFS（group 1）, 18% NFFS（group 2）, 27% NFFS（group 3）, and contained equivalent neutral detergent fiber and total digestible nutrients, respectively. The dry matter intake was similar among diets, averaging 3.33 kg d-1, and no differences were detected for body weight, withers height, body length and heart girth. In addition, the development of rumen, reticulum, omasum and abomasum also were similar among diets. Dry matter, crude protein, and neutral detergent fiber digestibilities increased with the increasing levels of NFFS in the experimental diets, but had no significant effect. Blood urea nitrogen, total protein and glubulin were not affected by the dietary treatment, but group 3 resulted in the highest（P〈0.05） concentrations of glucose and the lowest（P〈0.05） concentrations of triglycerides and albumin. In conclusion, dried distillers grains with solubles（DDGS） and corn germ meal（CGM） were available and alternative fiber sources for Holstein calf diets.
基金financed by China Agriculture Research System(CARS-41K15)Fund for Agro-scientific Research in the Public Interest (FARA200903006-01)China Agriculture Research System-Beijing Team for Poultry Industry
文摘Background： This study was conducted to evaluate the apparent metabolizable energy （AME） and true metabolizable energy （TME） contents in 30 sources of corn distillers dried grains with solubles （DDGS） in adult roosters, and establish the prediction equations to estimate the AME and TME value based on its chemical composition and color score. Methods： Twenty-eight sources of corn DDGS made from several processing plants in 11 provinces of China and others imported from the United States. DDGS were analyzed for their metabolizable energy （ME） contents, measured for color score and chemical composition （crude protein, crude fat, ash, neutral detergent fiber, acid detergent fiber）, to predict the equation of ME in DDGS. A precision-fed rooster assay was used, each DDGS sample was tube fed （50 g） to adult roosters. The experiment was conducted as a randomized incomplete block design with 3 periods. Ninety-five adult roosters were used in each period, with 90 being fed the DDGS samples and 5 being fasted to estimate basal endogenous energy losses. Results： Results showed that the AME ranged from 5.93 to 12.19 MJ/kg, TME ranged from 7.28 to 13.54 MJ/kg. Correlations were found between ME and ash content （-0.64, P 〈 0.0]） and between ME and yellowness score （0.39, P 〈 0.05） of the DDGS samples. Furthermore, the best-fit regression equation for AME content of DDGS based on chemical composition and color score was AME = 6.57111 ＋ 0.5]475 GE - 0.10003 NDF ＋ 0.1 3380 ADF ＋ 0.07057 fat - 0.57029 ash - 0.02437 L （R^2 = 0.70）. The best-fit regression equation for TME content of DDGS was TME = 7.92283 ＋ 0.51475 GE - 0.10003 NDF ＋ 0.13380 ADF ＋ 0.07057 fat - 0.57029 ash - 0.02437 L （R2 = 0.70）. Conclusions： This experiment suggested that measuring the chemical composition and color score of a corn DDGS sample may provide a quality parameter for identifying corn DDGS sources energy digestibility and metabolizable energy content.
基金supported by the Minnesota Corn Research and Promotion Council and the Agricultural Utilization Research Institute(Project number AIC-115)
文摘Corn distillers dried grains with solubles(DDGS) is a co-product of the fuel ethanol industry that is an excellent source of energy, digestible amino acids, and digestible phosphorus. However, the antioxidant capacity and phytochemical content of DDGS and how it is influenced by production parameters is unknown. Therefore, 16 DDGS samples obtained from different ethanol production plants in the U.S.were characterized for antioxidant capacity, vitamin E, xanthophylls, and ferulic acid content and compared with corn. The antioxidant capacity of DDGS samples, measured using the 2,2-diphenyl-lpicrylhydrazyl(DPPH) assay, varied almost 2 folds among samples, but in all cases was more than 3 times that of corn. All DDGS samples had a considerably greater concentration of tocopherols and tocotrienols(lipid-soluble antioxidants) than corn. However, the relative concentrations among the tocopherols and tocotrienols tended to be similar to corn. The xanthophyll lutein was present in all DDGS samples and in all cases exceeded the content in corn. Zeaxanthin was detected in most samples. The total ferulic acid content of the DDGS samples was almost 3-fold greater than corn, but, as in corn, almost all was present in a bound form. However, the concentration of unbound(free) ferulic acid was more than 3 times the concentration found in the corn sample. Thus, DDGS is a rich source of phytochemical compounds and may provide antioxidant and health benefits beyond its macronutrient composition. However, differences in processing can greatly influence the phytochemical content and quality of DDGS. In particular,thermal abuse due to excessive heat used in drying may lead to lipid oxidation products that may have deleterious effects when incorporated into feeds.
基金Financial support for this research from Enonik Industries AG,Rodenbacher Chaussee 4,63457,Hanau,Germany,is appreciated
文摘The primary objective of this experiment was to determine the effects of heat treatment on the standardized ileal digestibility （SID） of amino acids （AA） in corn distillers dried grains with solubles （DDGS） fed to growing pigs. The second objective was to develop regression equations that may be used to predict the concentration of SID AA in corn DDGS. A source of corn DDGS was divided into 4 batches that were either not autoclaved or autoclaved at 130℃ for 10, 20, or 30 min. Four diets containing DDGS from each of the 4 batches were formulated with DDGS being the only source of AA and CP in the diets. A N-free diet also was formulated and used to determine the basal endogenous losses of CP and AA. Ten growing pigs （initial BW： 53.5 ＋ 3.9 kg） were surgically equipped with a T-cannula in the distal ileum and allotted to a replicated 5 x4 Youden square design with 5 diets and 4 periods in each square. The SID of CP decreased linearly （P〈 0.05） from 77.9% in non-autoclaved DDGS to 72.1, 66.1, and 68.5% in the DDGS samples that were autoclaved for 10, 20, or 30 min, respectively. The SID of lysine was quadratically reduced （P〈 0.05） from 66.8% in the non-autoclaved DDGS to 54.9, 55.3, and 51.9% in the DDGS autoclaved for 10, 20, or 30 min, respectively. The concentrations of SID Arginine, Histidine, Leucine, Lysine, Methionine, Phenylalanine, or Threonine may be best predicted by equations that include the concentration of acid detergent insoluble N in the model （r2 = 0.76, 0.68, 0.67, 0.84, 0.76, 0.73, or 0.54, respectively）. The concentrations of SID Isoleucine and Valine were predicted （r2 = 0.58 and 0.54, respectively） by the Lysine：CP ratio, whereas the concentration of SID Tryptophan was predicted （r2 = 0.70） by the analyzed concentration of Tryptophan in DDGS. In conclusion, the SID of AA is decreased as a result of heat damage and the concentration of SID AA in heat-damaged DDGS may be predicted by regression equations developed in this experiment.
文摘Background： Post-production fractionation of wheat distillers grains with solubles（DDGS） increases their crude protein content and reduces their fiber content.This experiment was conducted to determine the effects of fractionation of wheat DDGS on apparent total tract digestibility（ATTD） and performance when fed to broiler chicks（0–21 d）.Methods： A total of 150,day-old,male broiler chicks（Ross-308 line;Lilydale Hatchery,Wynyard,Saskatchewan） weighing an average of 49.6 ± 0.8 g were assigned to one of five dietary treatments in a completely randomized design.The control diet was based on wheat and soybean meal and contained 20% regular wheat DDGS.The experimental diets contained 5,10,15 or 20% fractionated wheat DDGS added at the expense of regular wheat DDGS.Results： The ATTD of dry matter and gross energy were linearly increased（P 0.01） as the level of fractionated wheat DDGS in the diet increased.Nitrogen retention was unaffected by level of fractionated wheat DDGS（P 0.05）.Weight gain increased linearly（P = 0.05） as the level of fractionated wheat DDGS in the diet increased.Feed intake,feed conversion and mortality were unaffected by level of fractionated wheat DDGS in the diet（P 0.05）.Conclusions： Post-production fractionation of wheat DDGS improves their nutritional value by lowering their fiber content and increasing their content of crude protein and energy.These changes in chemical composition supported increased weight gain of broilers fed wheat DDGS.
基金Financial support for this research from Poet Nutrition,Sioux Falls,SD,is appreciated
文摘The objective of this experiment was to determine the standardized ileal digestibility（SID） of amino acids（AA） in 3sources of distillers dried grains with solubles（DDGS） with different concentrations of fat.Twelve growing barrows（initial body weight：76.1 ± 6.2 kg） were randomly allotted to a replicated 6×4 Youden square design with 6 diets and 4 periods.The fat content of the 3 sources of DDGS were 11.5,7.5,and 6.9%respectively.Diets contained 60%DDGS and fat concentration of the diets were 7.5,52,and 5.2%,respectively.Two additional diets containing the 2sources of DDGS with 75 and 6.9%fat were also formulated,and corn oil was added to these diets to increase the concentration of fat in the diets to levels that were calculated to be similar to the diet containing conventional DDGS with 11.5%fat.A N-free diet was also formulated to calculate endogenous losses of crude protein（CP） and AA from the pigs.Pigs were fed experimental diets during four 7-d periods.The first 5 d of each period were an adaptation period and ileal digesta were collected on d 6 and 7 of each period.The apparent ileal digestibililty（AID） and SID of CP and all indispensable AA,except AID Pro and SID of Trp,were greater（P 〈 0.01） in conventional DDGS than in the 2 sources of DDGS with reduced fat.Adding oil to the diets containing the 2 sources of DDGS with reduced fat did not consistently increase SID of AA.In conclusion,conventional DDGS has greater SID values for most AA compared with DDGS that contains less fat and inclusion of additional oil to diets containing low-fat DDGS does not increase AID or SID of AA.The lower AA digestibility in low-fat DDGS could not be overcome by the inclusion of additional fat to the diets.
文摘Soy molasses and soy solubles are byproducts of the conventional soy protein concentrate and soy protein isolate manufacturing processes,respectively.Conversion of the carbohydrates in these byproducts into ethanol was examined.Standardized amounts of commercial cellulase enzymes(Novozyme cellulase,β-glucosidase,and pectinase)were added to soy molasses and soy solubles solutions prepared at various solid loading rates(33%,50%,60%,75%,and 80%)to hydrolyze oligosaccharides,followed by fermentation for 96 h using Saccharomyces cerevisiae NRRL Y-2034 and Scheffersomyces stipitis NRRL Y-7124.Ethanol-extracted soybean meal(SBM)carbohydrates were also fermented for 96 h without enzymes.S.cerevisiae and S.stipitis produced about 12.5-45.0 g/L and 6.0-28.0 g/L ethanol,respectively,on molasses and solubles across these solid loading rates.The S.stipitis produced about 6.5-17 g/L ethanol and S.cerevisiae produced about 6.5-22 g/L ethanol on ethanol-extracted carbohydrates.
文摘This trial was conducted to determine the effects of graded levels of wheat distillers dried grains with solubles （DDGS） on nutrient digestibility, performance and carcass characteristics of pigs （21.8 to 112.3 kg） fed diets based on wheat and field peas. Forty crossbred pigs were assigned on the basis of sex and weight to one of five dietary treatments in a 5 x 2 （treatment x sex） factorial arrangement. The experimental diets were based on wheat and field peas and were formulated to contain 0, 4.86%, 9.71%, 14.57% or 19.42% wheat DDGS during the growing period and 0, 4.01%, 8.05%, 12.10% and 16.14% wheat DDGS during the finishing period. At the highest levels, ~vheat DDGS supplied 100% of the supplementary protein. The digestibility coefficient for gross energy showed a tendency towards a linear decline （P 〈 0.08 ） as the level of wheat DDGS in the diet increased while digestibility coefficients for dry matter and crude protein were unaffected （P 〉 0. 05 ） by inclusion level of wheat DDGS. During the growing period （21.8 to 60.8 kg）, weight gain of pigs fed wheat DDGS declined （P〈0.01） linearly. The impairment in growth appeared to be associated with a decrease in feed in- take which also declined linearly （P 〈 0.01 ） with increasing inclusion level of wheat DDGS. Feed conversion was unaffected by level of wheat DDGS. During the finishing period （60.8 to 112.3 kg）, and over the entire experimental period （21.8 to 112.3 kg ）, weight gain and feed conversion declined linearly as the dietary inclusion level of wheat DDGS increased. Carcass traits were generally unaffected by the inclusion of wheat DDGS with the exception of a trend towards a linear （P = 0.10） reduction in lean yield and a linear increase （ P = 0.09） in loin fat as the level of wheat DDGS in the diet increased. Overall, these results suggest that wheat DDGS are inferior to field peas as a supplementary protein source for use in swine rations.
文摘Distillers dried grains with solubles (DDGS) in combination with soy protein concentrate (SPC) with and without an essential amino acid (EAA) complex were assessed as protein alternatives in juvenile Yellow Perch Perca flavescens diets. Diets contained 5% FM, 40% SPC, and 20% or 40% DDGS each with or without EAA. No mortalities or health assessment differences were observed during the trial and all fish readily accepted the experimental diets. Diets supplemented with EAA produced greater weight gain, improved feed conversion, and apparent protein digestibility. Performance was consistently improved for fish fed diets containing amino acid supplements. Based on these results, Yellow Perch are able to utilize high levels of the plant proteins, accompanied with EAAs, as a FM replacer.
基金Financial support from Minnesota Pork Board,Agricultural Utilization and Research InstituteMinnesota Corn Growers Association is greatly appreciated
文摘Background： The immense growth in global bioethanol production has greatly increased the supply of by-products such as whole stillage and condensed distiller＇s solubles, which could be potentially used for animal feeding. The objective of this study was to investigate effects of liquid feeding high levels of corn condensed distiller＇s solubles（CCDS） and whole stillage（CWS） on growth performance, carcass characteristics, belly firmness and meat sensory traits of pigs.Methods： A total of 256 pigs were blocked by sex and initial BW（13.5 ± 2.5 kg）, and pens of pigs（8 pigs/pen） were randomly allocated to 1 of 4 dietary treatments（8 pens/treatment）： 1） corn-soybean meal based diet as control, 2） 25%CWS ＋ 5% CCDS, 3） 19.5% CWS ＋ 10.5% CCDS, and 4） 19.5, 26, and 32.5% CWS ＋ 10.5, 14, and 17.5% CCDS in phases 1（28 d）, 2（38 d）, and 3（60 d）, respectively. Inclusion levels of CCDS and CWS for Treatments 1, 2, and 3 were fixed during all the three phases of the experiment. Inclusion levels of CWS and CCDS were on 88% dry matter basis. The liquid feeding system delivered feed from the mixing tank to feed troughs by high-pressure air, had sensors inside feed troughs, and recorded daily feed intake on the basis of a reference feed intake curve. The pigs were fed 5 to 10 times per day with increasing frequency during the experiment.Results： Control pigs had greater（P 0.10） dressing percentage, loin muscle depth, and lean percentage were observed among the four treatments. Inclusion of CWS and CCDS reduced（P 0.10） the overall like,flavor, tenderness and juiciness of loin chops when compared with the control group.Conclusion： In conclusion, our results indicate that including 30–50% of a mixture of whole stillage and condensed distiller＇s solubles in the growing-finishing diets may reduce growth performance, carcass weight and belly firmness, but does not affect pork sensory traits.
文摘Pseudomonas putida KT217 was grown on a complex medium comprised of co-products of the ethanol and biodiesel industries to assess the organism's capability to produce medium-chain-length polyhydroxyalkanoate (mcl-PHA). The growth phase was carried out in a medium containing 400 g/L condensed corn solubles (CCS), supplemented with ammonium hydroxide as a nitrogen source. Following the exponential phase, co-products of the biodiesel industry (soapstock and glycerin) were fed into the reactor to trigger PHA production. When glycerin was added to the bioreactor (75 g/L total addition), the final cell dry weight (CDW) and PHA content were 30 g/L and 31%, respectively. The monomeric composition in the PHA formed was relatively uniform throughout incubation with 3-hydroxydecanoate dominating. When a total of 153 g/L of sunflower soapstock was added to the bioreactor in a fed-batch manner, the final CDW and PHA content were 17 g/L and 17%, respectively. Following addition of soapstock the monomeric composition of the polymer changed dramatically, with the 3-hydroxyoctanoate monomer becoming dominant and greater unsaturation present in the PHA.
基金supported by the National Natural Science Foundation of China(award No:31402101)the“One Belt and One Road”Technical Cooperation Project of Jiangsu Province(award No:BZ2018055)the Jiangsu Agriculture Science and Technology Innovation Fund(award No:CX(19)3023).
文摘Background:Diet has a profound impact on the rumen microbiota,and the impact can vary among the different rumen ecological niches(REN).This study investigated the effects of dietary replacement of soybean meal(SBM)with dried distillers grains with solubles(DDGS)on the rumen microbiota occupying different REN of growing Hu lambs.After a 9-week feeding trial,6 lambs from each dietary treatment(SBM vs.DDGS-based diets)were slaughtered for sample collection.The microbiota of the rumen solid,liquid,and epithelium fractions was examined using amplicon sequencing analysis of bacterial 16S rRNA gene,functional prediction,and qPCR.Results:No interaction of dietary protein source(PS)and REN were detected for virtually all the measurements made in this study.The DDGS substitution resulted in very limited influence on bacterial community structure.However,the metabolic pathways predicted from 16S rRNA gene sequences varied greatly between SBM-and DDGS-based diets.The populations of rumen total bacteria,fungi,sulfate-reducing bacteria(SRB),and methanogens were not influenced by DDGS substitution,but the population of protozoa was reduced.The bacterial communities in rumen solid(RS)and liquid(RL)were similar in taxonomic composition but were different in relative abundance of some taxa.In contrast,the bacterial composition and relative abundance of rumen epithelium(RE)were greatly distinct from those of the RS and the RL.In alignment with the bacterial relative abundance,the metabolic pathways predicted from 16S rRNA genes also varied greatly among the different REN.The populations of total bacteria,protozoa,and methanogens attached to the RE were smaller than those in the RS and RL,and the fungal population on the rumen epitheliumwas smaller than that in the RS but similar to that in the RL.On the contrary,the SRB population on the RE was greater than that in the RS and RL.Conclusions:Substitution of SBM with DDGS had greater impact to the protozoa than to the other microbes,and the microbial community structure and functions
基金supported by the South Dakota Corn Utilization Council and by the South Dakota Agricultural Experiment Station,grant no.SD00151-H.
文摘Scleroglucan is an extracellular polysaccharide produced by the fungi Sclerotium.Scleroglucan is stable over a broad range of temperatures,pH and salt concentration,thus having great potential in many diverse applications.Common media for scleroglucan production contain expensive components,such as yeast extract,that make the medium cost-ineffective for some industrial applications.Thus we developed a medium which uses Condensed Corn Solubles(CCS),a nutrient-rich byproduct of corn-based ethanol production,to replace expensive components.Methods typically used to recover scleroglucan are also expensive,and can limit commercialization.To evaluate alternative processes for scleroglucan recovery,we prepared scleroglucan in a modified version of Wang’s medium and a CCS-glucose medium.Broth samples were initially subjected to the standard recovery method to develop a complete mass balance,and then we evaluated various treatments to improve scleroglucan recovery.These included heat treatments to lyse cells,using different alcohol precipitants,freezing or refrigerating before recovery,and diluting broth to enhance cell separation.The CCS medium produced 14.2 g/L scleroglucan,compared to 10.1 g/L in the modified Wang’s medium.Based on the standard recovery protocol,we determined that 96%of the scleroglucan was recovered from the initial centrifugation and precipitation.Washing the cell pellet with water and recentrifuging only recovered a minimal amount of scleroglucan,and thus it could be eliminated from protocol to save energy and costs.Lysing cells by boiling or autoclaving did not release more scleroglucan than un-heated samples,and we also found no statistical difference between ethanol,isopopanol,and methanol as scleroglucan precipitants.Refrigerating the broth prior to scleroglucan recovery had no significant effect,while freezing actually decreased scleroglucan recovery.Initially diluting the broth by 0.50 or 0.34 resulted in the greatest scleroglucan recovery,while higher or lower dilutions decreased recovery
